服务电话:0553-8523136

ZYL中央链提升机 Bucket Lifter ZYL Series

发布时间:2016-12-23 10:55:00 点击量:


超强的链条强度,稳定的双链双斗双驱结构,合理的运转   速度确保输送能力每小时可高达1300立方米,两条链条连接一排料斗的提升机的高度由于两高,而中央链结构为一排料斗链接连接一条独立的链条,而两排料斗连接两条相互完全独立的链条和尾部张紧,除受自身重量限制外,不受左右链条长度偏差的限制,所以输送高度可达到68米的超高高度。

     The chain of super strength, stable double stranded double bucket double drive structure, reasonable running speed to ensure the delivery capacity per hour up to 1300 cubic meters, two chain hoist is connected with a discharge hopper height due to high, while the central chain structure of a discharge hopper link connected to a separate chain, and two discharge hopper is connected with two mutually independent chain and the tail tension, in addition to limit its own weight, about the length of the chain is not affected by the deviation limit, so the transport height can reach a height of 68 meters high.



      能适宜在较恶劣的工作环境下持续平稳运转,特殊的斗型还能适宜输 送湿度不大于20%的粘琢性物料:最适宜输送较高温度的出磨水泥,混合料,循环料及熟料等。

      It is suitable for continuous and stable operation in a bad working environment. Special bucket type also has the ability to transport the sticky material with humidity of not more than 20%. It is suitable for transporting cement, mixture, circulation material and clinker at higher temperature.

    配有方便安装与检修维护时用的慢速传动装置,料位报警装置,尾部测速装置。

     It is equipped with a slow speed driving device, an alarm device for a material position and a tail speed measuring device for the convenience of installation and maintenance.

    输送能力超过700立方米/小时可用双斗双链双驱结构配有可拆卸式的光齿摩擦链轮,与相对独立的尾部耐磨平衡张紧.The             Transport capacity is more than 700 cubic meters / hour, and the double bucket double chain double drive structure can be equipped with removable optical toothed friction sprocket, which is relatively balanced with the relatively independent tail wear.

    为了避免回料与卸料不顺畅,中央链提升机输送块状物料的链速选择不允许超过1.60m/s,输送微小颗粒状或粉状物料的链速选择不允许超过1.95m/s

     In order to avoid the unsmooth return and unloading, the chain speed of the central chain hoist can not exceed 1.60m / s, and the chain speed of conveying tiny granular or powdery materials is not allowed to exceed 1.95M / S.

技术参数(technical parameter)

(Actual transportation capacity)实际输送能力:520-1110m3
指示的输送能力相应于100%的装水装填量(The conveyed capacity of the instructions corresponds to 100% of the loading and filling of the water)
(It is recommended that the choice of filling amount should not be greater than)建议选择装填量不大于:75%
料    斗(hopper)
(theoretical capacity) 理论输送能力m3/h

输送最大输送能力时最大提升高度

(Maximum lift height at maximum conveying capacity)

链条
选型号(Chain selection model)
(width)宽度mm
(extension)伸出部分mm
(capacity)容积L
(gap)间距mm
(Chain speed)链速1.75m/s
800
285
33.00
356
585
65.00
8757
900
285
38.00
356
670
55.00
8757
1000
285
42.00
356
740
50.00
8757
2*800
285
66.00
356
1170
65.00
2*8577
2*900
285
76.00
356
1340
55.00
2*8577
2*1000
285
84.00
356
1480
50.00
2*8577

      高度计算时假设物料容重量为1.0t/m3,若容重不等于1.0t/m3时最大提升高度为参考数据除容重即得最大高度。提升高度指上下轮中心距离。

       (When height is calculated, the weight of the material is assumed to be 1.0t/m3,If the bulk weight is not equal to the maximum elevation of 1.0t/m3, the maximum height is obtained in addition to the bulk density. The lifting height refers to the distance between the center of the upper and lower wheel.)

      “2...’代表双链双斗双驱动结构。

     "2..." represent Double - stranded double - bucket dual drive structure.

    以上为常用的部分选型数据表,若有特殊的工作环境与要求,请联系私彩平台,我们将专门给您提供设计技术参数以及选型资料。

    (The above is a commonly used part selection data sheet. If there is a special working environment and requirements, please contact our company. We will provide you with design technical parameters and selection information.)

 

 

联系我们

地址:安徽新芜经济开发区西区经东路2158号
电话:0553-8523136
传真:0553-8523137
国内销售 E-mail:
ahbtxs@whbetter.com
国外销售 E-mail:
sterling.wang@whbetter.com
网站首页|关于百特|私彩平台|彩票中心|客户留言|在线订购|联系我们